Powered by GoogleTranslate

Occupational Safety and Health Administration OSHA

Inspection Detail

Case Status: CLOSED
Inspection: 63310.015 - Dakota Ag Cooperative

Inspection Information - Office: Bismarck

Nr: 63310.015Report ID: 0830300Open Date: 06/10/2011

Dakota Ag Cooperative
5324 165th Avenue Senull
Kindred, ND 58051
Union Status: NonUnion
NAICS: 424510/Grain and Field Bean Merchant Wholesalers
Mailing: 5500 Cenex Drivenull, Inver Grove Heights, MN 55077

Inspection Type:Fat/Cat
Scope:Complete Advanced Notice:N
Safety/Health:Safety Close Conference:06/10/2011
Emphasis: L:GrainClose Case:10/31/2011

Related Activity:TypeIDSafetyHealth
Case Status: CLOSED

Violation Summary
Serious Willful Repeat Other Unclass Total
Initial Violations 4 4
Current Violations 3 1 4
Initial Penalty $28,000 $0 $0 $0 $0 $28,000
Current Penalty $19,600 $0 $0 $0 $0 $19,600
FTA Amount $0 $0 $0 $0 $0 $0

Violation Items
# ID Type Standard Issuance Abate Curr$ Init$ Fta$ Contest LastEvent
  1. 01001 Serious 19100023 A08 08/11/2011 09/13/2011 $7,000 $7,000 $0 I - Informal Settlement
  2. 01002 Serious 19100023 C02 08/11/2011 09/13/2011 $5,600 $7,000 $0 I - Informal Settlement
  3. 01003 Other 19100272 E01 08/11/2011 09/13/2011 $0 $7,000 $0 I - Informal Settlement
  4. 01004 Serious 19100272 H03 08/11/2011 09/13/2011 $7,000 $7,000 $0 I - Informal Settlement

Accident Investigation Summary
Summary Nr: 2028.015Event: 06/09/2011Employee Is Engulfed In Corn Storage Building
At approximately 5:00 p.m. on June 9, 2011, Employee #1 was pushing corn with a front end loader in a flat storage building. The grain supervisor tried to cont act the employee via radio because the corn had stopped flowing through the sump hole onto the lower conveyor. The employee did not respond after three attempt s to contact him via radio. The grain supervisor then tried to contact the empl oyee via cell phone. The employee still did not respond. The grain supervisor then instructed a coworker to go to the corn storage building to check on Employ ee #1. When the employee got to the corn storage building, he found the front e nd loader running and the cab door open but could not locate Employee #1. A cowo rker went down into the conveyor tunnel below the corn strorage building to see if Employee #1 had gone down to check on the conveyor. Employee #1 was not in t he conveyor tunnel. The grounds around the flat storage building were checked a s well. The coworker radioed back to the grain supervisor that he could not loc ate Employee #1. The grain supervisor went to the flat storage building and ass umed the worst that Employee #1 had become engulfed in corn. Emergency personne l were summoned and a rescue attempt was undertaken. Shortly thereafter, the pr ocess became a recovery which lasted nearly 9 hours. Employee #1 was recovered from the sump hole in the floor of the flat storage building. There were no wit nesses to this event and the reasoning behind why Employee #1 exited the front e nd loader is still undetermined.
Keywords: asphyxiated, grain elevator
Inspection Degree Nature Occupation
1 63310.015 Fatality Laborers, except construction

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.