Translate
Inspection Detail
Inspection: 315460709 - Dean Stevens
Inspection Information - Office: Cincinnati Area Office
Site Address:
Dean Stevens
1501 Webster St.
Dayton, OH 45414
Mailing Address:
23833 Goose Creek Rd., South Bloomingville, OH 43152
Union Status: NonUnion
SIC:1795
NAICS: 238910/Site Preparation Contractors
Inspection Type: Accident
Scope: Partial
Advanced Notice: N
Ownership: Private
Safety/Health: Safety
Close Conference: 03/29/2011
Planning Guide: Safety-Construction
Emphasis: S:Struck-By
Case Closed: 08/16/2013
| Type | Activity Nr | Safety | Health |
|---|---|---|---|
| Accident | 101963148 | ||
| Referral | 201956976 | Yes |
| Violations/Penalties | Serious | Willful | Repeat | Other | Unclass | Total |
|---|---|---|---|---|---|---|
| Initial Violations | 7 | 7 | ||||
| Current Violations | 7 | 7 | ||||
| Initial Penalty | $25,800 | $0 | $0 | $0 | $0 | $25,800 |
| Current Penalty | $5,000 | $0 | $0 | $0 | $0 | $5,000 |
| FTA Penalty | $0 | $0 | $0 | $0 | $0 | $0 |
| # | Citation ID | Citaton Type | Standard Cited | Issuance Date | Abatement Due Date | Current Penalty | Initial Penalty | FTA Penalty | Contest | Latest Event | Note |
|---|---|---|---|---|---|---|---|---|---|---|---|
| 1. | 01001 | Serious | 19260020 B01 | 07/06/2011 | 07/18/2011 | $500 | $4,200 | $0 | 07/20/2011 | F - Formal Settlement | |
| 2. | 01002 | Serious | 19260020 B02 | 07/06/2011 | 07/12/2011 | $500 | $4,200 | $0 | 07/20/2011 | F - Formal Settlement | |
| 3. | 01003 | Serious | 19260021 B02 | 07/06/2011 | 07/12/2011 | $500 | $4,200 | $0 | 07/20/2011 | F - Formal Settlement | |
| 4. | 01004A | Serious | 19260350 A07 | 07/06/2011 | 07/12/2011 | $500 | $3,000 | $0 | 07/20/2011 | F - Formal Settlement | |
| 5. | 01004B | Serious | 19260350 A09 | 07/06/2011 | 07/12/2011 | $0 | $0 | $0 | 07/20/2011 | F - Formal Settlement | |
| 6. | 01005 | Serious | 19260350 H | 07/06/2011 | 07/12/2011 | $500 | $1,800 | $0 | 07/20/2011 | F - Formal Settlement | |
| 7. | 01006 | Serious | 19260850 A | 07/06/2011 | 07/12/2011 | $1,000 | $4,200 | $0 | 07/20/2011 | F - Formal Settlement | |
| 8. | 01007 | Serious | 19260858 D | 07/06/2011 | 07/11/2011 | $1,500 | $4,200 | $0 | 07/20/2011 | F - Formal Settlement |
Investigation Summary
On March 28, 2011, Employee #1, a 40-year-old male, was engaged in the demolition of a single story industrial building and was removing a section of a steel overhead I-beam that spanned twenty-six feet in a straight line. The I-beam was supported by three vertical 10 foot H-beam support columns. Employee #1 cut one of the outer most end support columns at the floor level completely in two. After cutting that column, the weight of the remaining steel structure became off balanced and caused the middle column and the third column to fall. Witnesses stated that it appeared that Employee #1 walked under the steel structure after making the first column cut. Witnesses also indicated that Employee #1 looked up as the structure began to fall on top of him, but he could not get away. Witnesses stated that after the worker cut the first column, there was approximately a four to five second pause before it fell over. The collapse started at the south end column, which had been cut, and then the middle column began to pull away from its concrete anchor supports. The third and last column held at the floor anchor supports, but the sheer weight bent that column over causing total collapse. Workers in the area ran to Employee #1's aid and used a 220 Komatsu excavator to lift the beams off of Employee #1 and move it away. Emergency responders pronounced Employee #1 dead at the scene.
Keywords: WELDER, COLUMN, CRUSHED, STRUCK BY
| # | Inspection | Age | Sex | Degree of Injury | Nature of Injury | Occupation |
|---|---|---|---|---|---|---|
| 1 | 315460709 | Fatality | Other | Construction laborers |