Powered by GoogleTranslate

Occupational Safety and Health Administration OSHA

Inspection Detail

Inspection: 310716600 - Isg Plate Llc

Inspection Information - Office: Philadelphia

Nr: 310716600Report ID: 0317000Open Date: 05/27/2007

Isg Plate Llc
139 Modena Road
Coatesville, PA 19320
Union Status: Union
SIC: 3325/Steel Foundries, Not Elsewhere Classified
NAICS: 331513/Steel Foundries (except Investment)
Mailing: 139 Modena Road, Coatsville, PA 19320

Inspection Type:Accident
Scope:Partial Advanced Notice:N
Ownership:Private
Safety/Health:Safety Close Conference:10/30/2007
Emphasis: S:Fall From HeightClose Case:09/16/2008

Related Activity:TypeIDSafetyHealth
 Accident102021946    

Violation Summary
Serious Willful Repeat Other Unclass Total
Initial Violations 5 5
Current Violations 3 3
Initial Penalty $20,000 $0 $0 $0 $0 $20,000
Current Penalty $11,000 $0 $0 $0 $0 $11,000
FTA Amount $0 $0 $0 $0 $0 $0

Violation Items
# ID Type Standard Issuance Abate Curr$ Init$ Fta$ Contest LastEvent
Deleted 1. 01001 Serious 5A0001 11/13/2007 12/16/2007 $2,500 $2,500 $0 12/05/2007 F - Formal Settlement
  2. 01002 Serious 19100023 C01 11/13/2007 11/17/2007 $2,500 $5,000 $0 12/05/2007 F - Formal Settlement
  3. 01003A Serious 19100132 A 11/13/2007 11/17/2007 $2,500 $5,000 $0 12/05/2007 F - Formal Settlement
  4. 01003B Serious 19100132 F01 I 11/13/2007 11/17/2007 $0 $0 $0 12/05/2007 F - Formal Settlement
Deleted 5. 01004A Serious 19100147 C04 I 11/13/2007 11/26/2007 $0 $5,000 $0 12/05/2007 F - Formal Settlement
Deleted 6. 01004B Serious 19100147 C07 IA 11/13/2007 11/26/2007 $0 $0 $0 12/05/2007 F - Formal Settlement
  7. 01005A Serious 5A0001 11/13/2007 12/16/2007 $6,000 $2,500 $0 12/05/2007 F - Formal Settlement
  8. 01005B Serious 19100147 C07 IA 11/13/2007 11/26/2007 $0 $0 $0 12/05/2007 F - Formal Settlement

Accident Investigation Summary
Summary Nr: 202004982Event: 05/26/2007One Employee Is Killed, Two Are Injured In Furnace Explosion
At approximately 9:30 p.m. on May 26, 2007, Employee#1, Employee #2 and Employee #3, three steelworkers, were working immediately adjacent to a 165-ton rated electric arc furnace (EAF). It is believed that a stray electrical arc created a significant internal water leak on one of the water-cooled shell panels. The spraying water accumulated within the furnace. When the temperature of the molten steel was finally up to pouring temperature (approximately 3,000 degrees Fahrenheit), the employees found that the furnace's tap hole was blocked. There were several unsuccessful attempts to unblock this tap hole. The employees' final attempt involved putting a lit oxygen lance down into the tap hole and burning clear whatever was causing the block. During this activity, the EAF violently erupted. After the bath of molten steel solidified, it was observed that it contained a largely intact bale of scrap steel. This bale likely had been stuck to the furnace shell and above the molten steel bath. This bale probably fell into the molten steel bath in the same area where the water had been spraying and accumulating, causing the accumulated water to be engulfed by the molten steel. This water rapidly turned to superheated steam that developed vast pressure. The release of this pressurized steam when it broke through the surface of the molten metal caused the furnace to explode. Each employee received partial and full thickness steam burns over large parts of their bodies, as well as internally. Employees #1 and #3 were hospitalized. Employee #2 died the following day. At the time of the incident, the three workers were not wearing high-heat coats and hoods. The employee using the oxygen lance was blown completely off the furnace spout platform and into the pit approximately 30 feet below. There was no guardrail on the platform at the time of the incident. There were no written procedures for clearing a blocked tap hole. There were no written procedures for what to do when there was significant water in the furnace.
Keywords: burn, maintenance, steel-melting furn, protective clothing, work rules, steam, explosion, molten metal, pressure release
Inspection Degree Nature Occupation
1 310716600 Hospitalized injury Burn/Scald(Heat) Occupation not reported
2 310716600 Fatality Burn/Scald(Heat) Occupation not reported
3 310716600 Hospitalized injury Burn/Scald(Heat) Occupation not reported

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close