Powered by GoogleTranslate

Occupational Safety and Health Administration OSHA

Inspection Detail

Violation Summary
Serious Willful Repeat Other Unclass Total
Initial Violations 1 1
Current Violations 1 1
Initial Penalty $0 $0 $0 $0 $0 $0
Current Penalty $0 $0 $0 $0 $0 $0
FTA Amount $0 $0 $0 $0 $0 $0

Violation Items
# ID Type Standard Issuance Abate Curr$ Init$ Fta$ Contest LastEvent
  1. 01001 Other 5144 I01 B 03/03/2000 04/18/2000 $0 $0 $0 I - Informal Settlement

Accident Investigation Summary
Summary Nr: 201792710 Event: 09/26/1999Three Employees Fall Unconcious - None Hospitalized
On September 26, 1999, Employee #1, Employee #2, and Employee #3 were participating in a training drill. All three employees were assigned to the decontamination team, which is responsible for decontaminating hazardous materials response members. The team was suited in level B protective gear and was utilizing Self Contained Breathing Apparatus. The team was using a "buddy breather" system, which allowed the team to switch from breathing air from a cylinder to an airline drawing air from Air Utility-21 air tanks. The Air Utility-21 airline system consisted of 300 ft of Synflex hose (an internal part of system), a manifold, and three separate 75-ft portable Gates Premoflex airline hoses. The manifold was capable of splitting the compressor's airlines into five 50-ft lines; however for the purpose of this drill, three 75-ft lines were used. Employee #1 was the first of the three team members to switch to breathing air from the Air Utility-21 airline. Employees #2 and #3 switched onto the airline a few seconds later. Employee #1 reported that after approximately 10 seconds, he began to feel dizzy. Employee #1 stopped and bent over to rest and informed Employees #2 and #3 to suit-up. Employee #1 recalls walking away from Employee #2 and #3, stumbling and tripping. Employee #1 then fell, face-forward, onto the floor, but does not remember this. The impact of Employee #1's fall resulted in a laceration to his nose and forehead caused by the impact of his face hitting his respirator face piece. This injury required stitches. The next thing Employee #1 remembered was being aware of firemen picking him up and providing him with first aid. Employee #2 connected to the airline after Employee #1. Employee #2 recalls that after approximately two breaths, he began to feel dizzy and thought that he may have stood up to quickly which he reasoned was the cause of his dizziness. After a dozen more breaths, Employee #2 felt lightheaded, nauseated, dizzy, and had hazy vision. Employee #2 then looked towards Employees #1 and #3 to see what they were doing and disconnected himself from the airline. Employee #2 took a few steps towards Employee #3 and yelled at him to "go off air." Employee #2 then realized Employee #1 was down on the floor. Employee #3 switched over to breathe air off of the airline shortly after Employee #2. After one or two breaths, Employee #3 recalls having difficulty with his manual dexterity, having a hard time attaching a hook that holds his breathing apparatus, and felt that he had tunnel vision. After approximately 10 seconds of breathing air from the airline, Employee #2 yelled at him to disconnect himself from the airline. Employee #3 disconnected from the airline, estimating that he had breathed air from the line for no more than 15 seconds. At this time, he noticed that Employee #1 was on the ground. Paramedics were present at the drill and took the vitals of all three team members and placed them on oxygen for 20 minutes. All three employees were then taken to the hospital and treated but not hospitalized.
Keywords: firefighter, oxygen deficiency, unconsciousness, air line respirator, compressed air, laceration, scba, dizziness, air line
Inspection Degree Nature Occupation
1 120258371 Non Hospitalized injury Cut/Laceration Firefighting occupations
2 120258371 Non Hospitalized injury Other Firefighting occupations
3 120258371 Non Hospitalized injury Other Firefighting occupations

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.