Translate
Inspection Detail
Inspection: 300756368 - Office Depot
Inspection Information - Office: Long Beach District Office
Site Address:
Office Depot
3366 E Willow St
Signal Hill, CA 90806
Mailing Address:
, , 00000
Union Status: NonUnion
SIC:5046
NAICS: 0
Inspection Type: Accident
Scope: Partial
Advanced Notice: N
Ownership: Private
Safety/Health: Safety
Close Conference: 07/08/1998
Planning Guide: Safety-Construction
Emphasis:
Case Closed: 03/15/2000
| Type | Activity Nr | Safety | Health |
|---|---|---|---|
| Accident | 362028789 |
| Violations/Penalties | Serious | Willful | Repeat | Other | Unclass | Total |
|---|---|---|---|---|---|---|
| Initial Violations | 2 | 3 | 5 | |||
| Current Violations | 2 | 2 | 4 | |||
| Initial Penalty | $8,750 | $0 | $0 | $1,125 | $0 | $9,875 |
| Current Penalty | $3,750 | $0 | $0 | $750 | $0 | $4,500 |
| FTA Penalty | $0 | $0 | $0 | $0 | $0 | $0 |
| # | Citation ID | Citaton Type | Standard Cited | Issuance Date | Abatement Due Date | Current Penalty | Initial Penalty | FTA Penalty | Contest | Latest Event | Note |
|---|---|---|---|---|---|---|---|---|---|---|---|
| 1. | 01001 | Other | 342 A | 09/08/1998 | 09/25/1998 | $375 | $375 | $0 | J - ALJ Decision | ||
| 2. | 01002 | Other | 14304 A | 09/08/1998 | 09/25/1998 | $375 | $375 | $0 | J - ALJ Decision | ||
| 3. | 01003 | Other | 3203 A | 09/08/1998 | 09/25/1998 | $0 | $375 | $0 | J - ALJ Decision | Citation has been deleted. | |
| 4. | 02001 | Serious | 4002 A | 09/08/1998 | 09/25/1998 | $2,500 | $2,500 | $0 | - | ||
| 5. | 03001 | Serious | 4001 | 09/08/1998 | 09/25/1998 | $1,250 | $6,250 | $0 | J - ALJ Decision |
Investigation Summary
Employee #1, a temporary general laborer at a regional distribution center of office supplies, was standing on a 3 in. support beam of the central conveyor, approximately 24 ft above the floor, wedged between the conveyor belt and the wall. He was bent over the belt, holding down the diverter swing arm so that boxes could continue going down the conveyor line. This was a company-built conveyor system that went around the facility. There was a 24 ft high platform which allowed access to parts of sections #1 and #2 of the line. Employee #1's left hand became caught in the in-running nip point of the rollers of section #2 and the belt below it, and he sustained severe abrasions of his third, fourth, and fifth fingers. He was hospitalized for treatment and underwent two surgical repairs. The in-going nip points of the rollers on section #2 were not guarded, and there was no easily accessible method of shutting off the machine immediately after Employee #1's hand became caught.
Keywords: FINGER, WORK RULES, EMERGENCY STOP, ROLLER--MACH/PART, CAUGHT BETWEEN, ABRASION, CONVEYOR, NIP POINT, CONVEYOR BELT, UNGUARDED
| # | Inspection | Age | Sex | Degree of Injury | Nature of Injury | Occupation |
|---|---|---|---|---|---|---|
| 1 | 300756368 | Hospitalized injury | Bruise/Contus/Abras | Laborers, except construction |