Translate
Inspection Detail
Inspection: 125872929 - Arnie'S Door & Installation Service
Inspection Information - Office: San Diego District Office
Site Address:
Arnie'S Door & Installation Service
University & Park Blvd
San Diego, CA 92103
Mailing Address:
1360 Hill St, El Cajon, CA 92020
Union Status: NonUnion
SIC:1751
NAICS: 238130/Framing Contractors
Inspection Type: Accident
Scope: Partial
Advanced Notice: N
Ownership: Private
Safety/Health: Safety
Close Conference: 10/25/2005
Emphasis:
Case Closed: 09/13/2010
| Type | Activity Nr | Safety | Health |
|---|---|---|---|
| Accident | 362423956 |
| Violations/Penalties | Serious | Willful | Repeat | Other | Unclass | Total |
|---|---|---|---|---|---|---|
| Initial Violations | 1 | 2 | 3 | |||
| Current Violations | 1 | 2 | 3 | |||
| Initial Penalty | $10,800 | $0 | $0 | $410 | $0 | $11,210 |
| Current Penalty | $10,800 | $0 | $0 | $410 | $0 | $11,210 |
| FTA Penalty | $0 | $0 | $0 | $0 | $0 | $0 |
| # | Citation ID | Citaton Type | Standard Cited | Issuance Date | Abatement Due Date | Current Penalty | Initial Penalty | FTA Penalty | Contest | Latest Event | Note |
|---|---|---|---|---|---|---|---|---|---|---|---|
| 1. | 01001 | Other | 1509 A | 11/07/2005 | 12/10/2005 | $280 | $280 | $0 | D - Govt Dismissed | ||
| 2. | 01002 | Other | 1509 C | 11/07/2005 | 12/05/2005 | $130 | $130 | $0 | D - Govt Dismissed | ||
| 3. | 02001 | Serious | 3382 A | 11/07/2005 | 11/18/2005 | $10,800 | $10,800 | $0 | 12/01/2005 | D - Govt Dismissed |
Investigation Summary
At approximately 9:00 a.m. on June 13, 2005, Employee #1 was assigned by the employer to install stainless steel kick plates on prehung exterior doors in the building. Employee #1 was using a Makita 14.4-volt cordless drill (Model No. 63370; Serial No. 519429A) and a cordless screwdriver. He had ZTEK model clear plastic safety glasses with an ANSI Z87.1 impact-resistant rating, but he was not wearing them at the time of the accident. Employee #1 was kneeling on the ground and hunched over so that his left shoulder was on or near the ground. He was holding the drill in his left hand, trying to keep the drill bit level and at a right angle to the door as he drilled the bottom row of holes into the door for the kick plate installation. As he was drilling the last hole at the inside corner, the drill bit broke in half, and the sharp end of the drill bit flew into his left eye, puncturing it and causing corneal damage. Employee #1 was hospitalized.
Keywords: EYE, PPE, CONSTRUCTION, EQUIPMENT FAILURE, FLYING OBJECT, ELECTRIC DRILL, PUNCTURE
| # | Inspection | Age | Sex | Degree of Injury | Nature of Injury | Occupation |
|---|---|---|---|---|---|---|
| 1 | 125872929 | Hospitalized injury | Foreign Body Ineye | Carpenters |