Translate
Inspection Detail
Inspection: 120325444 - United Riggers & Erectors Inc
Inspection Information - Office: Long Beach District Office
Site Address:
United Riggers & Erectors Inc
500 Crenshaw Bl
Torrance, CA 90503
Mailing Address:
12222 E Florence Av, Santa Fe Spring, CA 90670
Union Status: Union
SIC:9999
NAICS: 0
Inspection Type: Accident
Scope: Partial
Advanced Notice: N
Ownership: Private
Safety/Health: Safety
Close Conference: 12/13/1996
Planning Guide: Safety-Construction
Emphasis:
Case Closed: 06/17/1998
| Type | Activity Nr | Safety | Health |
|---|---|---|---|
| Accident | 362026502 |
| Violations/Penalties | Serious | Willful | Repeat | Other | Unclass | Total |
|---|---|---|---|---|---|---|
| Initial Violations | 3 | 5 | 8 | |||
| Current Violations | 1 | 3 | 4 | |||
| Initial Penalty | $9,030 | $0 | $0 | $1,500 | $0 | $10,530 |
| Current Penalty | $1,375 | $0 | $0 | $275 | $0 | $1,650 |
| FTA Penalty | $0 | $0 | $0 | $0 | $0 | $0 |
| # | Citation ID | Citaton Type | Standard Cited | Issuance Date | Abatement Due Date | Current Penalty | Initial Penalty | FTA Penalty | Contest | Latest Event | Note |
|---|---|---|---|---|---|---|---|---|---|---|---|
| 1. | 01001 | Other | LC6431 | 12/20/1996 | 01/17/1997 | $275 | $275 | $0 | 01/22/1997 | J - ALJ Decision | |
| 2. | 01002 | Other | 1509 C | 12/20/1996 | 01/17/1997 | $0 | $340 | $0 | 01/22/1997 | F - Formal Settlement | |
| 3. | 01003 | Other | 3664 A | 12/20/1996 | 01/17/1997 | $0 | $340 | $0 | 01/22/1997 | F - Formal Settlement | Citation has been deleted. |
| 4. | 01004 | Other | 1512 C01 | 12/20/1996 | 01/17/1997 | $0 | $205 | $0 | 01/22/1997 | F - Formal Settlement | |
| 5. | 01005 | Other | 1734 B | 12/20/1996 | 01/17/1997 | $0 | $340 | $0 | 01/22/1997 | F - Formal Settlement | Citation has been deleted. |
| 6. | 02001 | Serious | 3661 C | 12/20/1996 | 01/07/1997 | $0 | $1,030 | $0 | 01/22/1997 | J - ALJ Decision | Citation has been deleted. |
| 7. | 03001 | Serious | 1734 B | 12/20/1996 | 01/02/1997 | $1,375 | $4,000 | $0 | 01/22/1997 | F - Formal Settlement | |
| 8. | 04001 | Serious | 1735 D | 12/20/1996 | 01/02/1997 | $0 | $4,000 | $0 | 01/22/1997 | F - Formal Settlement | Citation has been deleted. |
Investigation Summary
At about 11 a.m. on October 24, 1996, Employee #1, of United Riggers & Erectors, was engaged in demolition of a cup platform in the draw and iron department of the Reynolds Metal Company. His supervisor was operating a forklift truck and directing the demolition operation. The platform was an approximately 25 ft by 12 ft steel plate supported by two 25 ft long I-beams spaced about 12 ft apart. The 16 in. deep beams had 8 in. flanges supporting the steel plate at each end. The entire platform had been marked into three approximately 8 ft 3 in. by 12 ft panels. The procedure for removing each panel was to first cut the plate and to then cut the beam, while it was being supported by the lift forks. No problems were encountered in removing the first panel. With the second panel, the beam on the east side was originally welded by stitch to the plate on both the inside and outside of the beam flange. The inside weld was cut in the hope the beam piece could be retrieved and used. The west side beam weld on the inside was cut for the same reason, and it was assumed the beam flange on the west side was also welded to the plate on the outside. This assumption was not correct. The forklift was holding the panel at the bottom and the third welder cut the beam lengthwise on the east side followed by the beam on the west side. As soon as the west side beam length was cut, it became loose because there was no weld between the outer flange and the plate. Moments before this, Employee #1 had moved under the west side of the second panel to warn a coworker who had disregarded the caution signs and was walking in the area. The loose beam fell to the ground, striking Employee #1 on the back. This accident resulted from failure to check whether the west side beam flange on the second panel was welded to the plate, and failure to take adequate safety measures to support and brace the beam during demolition.
Keywords: BEAM, DEMOLITION, UNSECURED, WORK RULES, BACK, MILLWRIGHT, STRUCK BY, BRACING, FALLING OBJECT
| # | Inspection | Age | Sex | Degree of Injury | Nature of Injury | Occupation |
|---|---|---|---|---|---|---|
| 1 | 120325444 | Hospitalized injury | Strain/Sprain | Millwrights |