Translate
Inspection Detail
Inspection: 106511090 - Forster Masonry Inc.
Inspection Information - Office: Appleton Area Office
Site Address:
Forster Masonry Inc.
1601 N. Quincy Street
Green Bay, WI 54302
Mailing Address:
810 E. Pershing, Appleton, WI 54911
Union Status: NonUnion
SIC:1741
NAICS: 0
Inspection Type: Unprog Rel
Scope: Complete
Advanced Notice: N
Ownership: Private
Safety/Health: Safety
Close Conference: 01/03/1992
Planning Guide: Safety-Construction
Emphasis:
Case Closed: 02/04/1992
| Type | Activity Nr | Safety | Health |
|---|---|---|---|
| Accident | 360408736 |
| Violations/Penalties | Serious | Willful | Repeat | Other | Unclass | Total |
|---|---|---|---|---|---|---|
| Initial Violations | 2 | 2 | ||||
| Current Violations | 2 | 2 | ||||
| Initial Penalty | $450 | $0 | $0 | $0 | $0 | $450 |
| Current Penalty | $450 | $0 | $0 | $0 | $0 | $450 |
| FTA Penalty | $0 | $0 | $0 | $0 | $0 | $0 |
| # | Citation ID | Citaton Type | Standard Cited | Issuance Date | Abatement Due Date | Current Penalty | Initial Penalty | FTA Penalty | Contest | Latest Event | Note |
|---|---|---|---|---|---|---|---|---|---|---|---|
| 1. | 01001 | Serious | 19260451 D10 | 01/22/1992 | 01/27/1992 | $225 | $225 | $0 | - | ||
| 2. | 01002 | Serious | 19260451 A13 | 01/22/1992 | 01/27/1992 | $225 | $225 | $0 | - |
Investigation Summary
At approximately 3:15 a.m. on December 28, 1991, Employee #1, a paper machine back tender, was helping to re-align a blanket on a paper machine. His job was to start the press in crawl mode while coworkers watched the blanket to make sure it would align itself and run true over the rolls. After starting the machine in crawl mode, Employee #1 went to the back of the paper machine and onto a catwalk in the blanket area of the machine. His supervisor was also on the catwalk. A nip point, created by the blanket going over a roll to meet the felt, was located about 5 ft from the catwalk. A few feet past that nip point was a press nip. Employee #1's hand caught the felt/blanket nip. He yelled to turn the machine off, but his hand was then pulled into the press nip and his body was pulled between the felt and blanket nip. Only his legs were left protruding out of the felt/blanket nip. Employee #1 died of asphyxiation.
Keywords: ROLLER--MACH/PART, NIP POINT, PAPER MACHINE, PRESS, CAUGHT BY, ASPHYXIATED, HAND, CRUSHED
| # | Inspection | Age | Sex | Degree of Injury | Nature of Injury | Occupation |
|---|---|---|---|---|---|---|
| 1 | 106511090 | Occupation Not Listed |