US Dept of Labor

Occupational Safety & Health AdministrationWe Can Help

OSHA News Release - (Archived) Table of Contents
Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.
Trade News Release Banner Image

Region 8 News Release:   OSHA 02-46
Monday, Jan 06, 2003
Contact: Rich Kulczewski
Phone: (303)844-1302


Plum Creek's MDF Plant in Columbia Falls issued $169,000
in proposed penalties for safety violations

BILLINGS, Mont. -- The failure of a Montana employer to protect employees working on a conveyor system has resulted in $169,000 in proposed penalties issued against the Plum Creek MDF plant in Columbia Falls, following an investigation by the Occupational Safety and Health Administration into a fatal accident at the plant in July.

OSHA's Billings area office issued one willful, eight serious, two repeat and one failure-to-correct citation following an investigation that began on July 11. The conveyor accident at the plant took the life of an employee with Workplace Inc., a company that supplies manpower to the Plum Creek facility. Workplace Inc. was not cited.

"This accident and the unsafe conditions discovered during the inspection could have been avoided by adherence to recognized safe work practices and OSHA regulations, said David DiTommaso, OSHA area director in Billings.

Plum Creek was cited for one willful violation for equipment lock out hazards including failure to de-energize equipment before employees worked on it, not locking equipment out of service and not having authorized employees perform machinery lock outs. A $70,000 fine is proposed for this violation.

OSHA also found two alleged repeat violations for failure to protect employees from hazardous parts on conveyors and unguarded chains and sprockets and assessed penalties of $37,500 for those violations.

Eight alleged serious violations address their failure to: provide emergency stops on conveyors and alarms for conveyors that start automatically; provide fall protection for employees working above dangerous equipment; provide identifiable locks used for lockouts along with lockout training; verify that equipment was de-energized before working on it; provide guarded projecting shaft ends, belts and pulleys; and using compressed air for cleaning purposes in excess of safe pressure. The penalty for the serious violations totaled $31,500.

A total of $30,000 in penalties also was proposed for Plumb Creek's failure to correct a previous citation that had required the company to prepare written machinery lockout procedures.

Willful violations are those committed with an intentional disregard of, or plain indifference to, the requirements of the Occupational Safety and Health Act. A repeat violation occurs when a previously cited hazard is corrected but allowed to re-occur. A serious violation is one where there is substantial probability that death or serious physical harm could result, and the employer knew or should have known of the hazard.

Plum Creek has 15 working days from receipt of the citations to request an informal conference with the OSHA area director, or to contest the citations and proposed penalties before the independent Occupational Safety and Health Review Commission.

The Occupational Safety and Health Administration is dedicated to saving lives, preventing injuries and illnesses, and protecting America's workers. Safety and health add value to business, the workplace and life. For more information, visit www.osha.gov.

###

Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.

OSHA News Release - (Archived) Table of Contents

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close