US Dept of Labor

Occupational Safety & Health AdministrationWe Can Help

OSHA News Release - (Archived) Table of Contents
Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.
Trade News Release Banner Image

Region 4 News Release   USDOL: 02-214
Wed., Oct. 30, 2002
Contact: Jo Anne Burgoyne
Phone: (404) 562-2076


Safety Hazards At Florida Grain Silo Bring $161,000 OSHA Fine
Lack of Safety Harness Factor in Worker's Death

BUSHNELL, Fla. -- Safety hazards at a Bushnell grain silo, which led to the death of a worker, could cost Hillandale Farms of Florida, Inc., $161,000 in proposed penalties according to citations issued today by the U.S. Department of Labor's Occupational Safety and Health Administration.

"The Department of Labor will vigorously enforce safety standards for workers in grain silos," said John Henshaw, assistant secretary of labor for occupational safety and health and head of OSHA. "This was a tragic accident that should have been avoided."

The accident occurred on the afternoon of May 1 while three workers were emptying a corn silo. Two remained outside the silo. The third entered through a hatchway. He descended a ladder attached to the inside of the 42-foot-high silo and began dislodging corn that had become caked to its side. The worker was also tasked with keeping the corn flowing through the silo down to a processing area, a job that required leaving the ladder.

About 30 minutes after entering the silo, the worker, who wore no protective equipment, radioed to his co-workers that he was sinking. The machinery was stopped but the worker was already buried chest-deep. Co-workers attempted to pull him out but failed before calling emergency rescue personnel who were also unable to free the worker. Four hours after being entrapped, he died of asphyxiation due to the pressure of the corn on his chest.

"This employer allowed workers to enter operating silos without body harnesses or other protective equipment," said Les Grove, OSHA's Tampa area director. "In addition, nothing was done to stop workers from 'walking the corn,' a recognized industry hazard that can result in engulfment. This time it cost a worker his life."

During the investigation, OSHA inspectors warned the company about the danger of dust accumulation, as much as 18 inches in some areas. Yet, tests taken a few weeks after the accident revealed that no action had been taken to remove the dust. On May 30, the agency posted a Notice of Imminent Danger due to the potential for a grain dust explosion.

Hillandale Farms of Florida received two willful citations with proposed penalties totaling $125,000 for allowing employees without lifelines or body harnesses to enter grain silos and for failing to remove grain dust as it accumulated in the mill.

The agency fined the company $36,000 for seven additional serious citations for failing to have in place an emergency action plan, including emergency shutdown procedures and maintenance of emergency rescue equipment; failing to issue entry permits for confined spaces; not conducting employee safety training, and failure to develop and implement a written housekeeping program to eliminate grain dust accumulations.

Hillandale Farms has 15 working days to contest the OSHA citations and proposed penalties before the independent Occupational Safety and Health Review Commission.

Inspection of the Bushnell facility was conducted by the Tampa OSHA area office located at 5807 Breckenridge Pkwy, Suite A; phone: (813) 626-1177.


###

Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.

OSHA News Release - (Archived) Table of Contents

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close