US Dept of Labor

Occupational Safety & Health AdministrationWe Can Help

OSHA News Release - (Archived) Table of Contents
Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.
Trade News Release Banner Image


Region 2 News Release:    05-1988-NEW/BOS 2005-289
Wednesday, October 19, 2005
Contact: Ted Fitzgerald
Phone: (617) 565-2074


Hornell, N.Y., Railroad Car Manufacturer Faces $130,500 in OSHA Fines for Safety and Health Hazards

SYRACUSE, N.Y. -- A cross section of safety and health hazards at a Hornell, N.Y., manufacturer and refurbisher of railroad cars has resulted in $130,500 in fines from the U.S. Labor Department's Occupational Safety and Health Administration (OSHA).

Alstom Transportation Inc. was cited for a total of 17 alleged willful and serious violations of workplace safety and health standards at its Alstom Drive plant. The citations result from an OSHA inspection begun April 18 under OSHA's site-specific targeting program which directs inspections to workplaces with illness and injury rates higher than the industry average.

Two willful citations, which account for $99,000 in fines, were issued for hazards involving large overhead cranes. The first citation concerned an employee exposed to falls of up to 45 feet due to his being required to climb over a crane wheel to access the crane's cab; the second citation addressed the company's failure to correct this and other unsafe conditions, including no load rating capacity and missing runway rail sweeps, identified during safety inspections of three cranes.

"Employees should not have been allowed to operate these cranes until these hazards had been fixed," said Chris R. Adams, OSHA's Syracuse area director. "Management knew these hazards existed, yet took no steps to correct them."

OSHA's inspection identified other hazards in the plant, including unguarded floors and runways; unguarded machinery; improper storage of compressed gas cylinders; storage of excess amounts of flammable liquids; electrical hazards; no eyewash where employees worked with corrosive liquids; employees exposed to excess levels of cadmium; and employees exposed to being struck by a high pressure water stream operating at 38,000 pounds per square inch. These resulted in the issuance of 15 serious citations and $31,500 in fines.

OSHA defines a willful violation as one committed with an intentional disregard of, or plain indifference to, the requirements of the Occupational Safety and Health Act and regulations. A serious citation is issued when death or serious physical harm are likely to result from a hazard about which the employer knew or should have known.

The company has 15 business days from receipt of its citations to comply with them, to request and participate in an informal conference with the OSHA area director, or to contest them before the independent Occupational Safety and Health Review Commission. The investigation was conducted by OSHA's area office located at 3300 Vickery Rd., North Syracuse; telephone: (315) 451-0808.

Employers are responsible for providing a safe and healthful workplace for their employees. OSHA's role is to assure the safety and health of America's workers by setting and enforcing standards; providing training, outreach and education; establishing partnerships; and encouraging continual improvement in workplace safety and health. For more information, visit www.osha.gov.


# # #


U.S. Labor Department releases are accessible on the Internet at www.dol.gov. The information in this news release will be made available in alternate format upon request (large print, Braille, audio tape or disc) from the COAST office. Please specify which news release when placing your request. Call (202) 693-7773 or TTY (202) 693-7755. The U.S. Department of Labor is committed to providing America's employers and employees with easy access to understandable information on how to comply with its laws and regulations. For more information, please visit www.dol.gov/compliance.


Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.

OSHA News Release - (Archived) Table of Contents

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close