US Dept of Labor

Occupational Safety & Health AdministrationWe Can Help

Standard Interpretations - Table of Contents
• Standard Number: 1910.1200

May 6, 1986

Mr. Ed Starbuck
Vice President - Operations
San Joaquin Refining Co., Inc.
Standard & Shell Streets
P.O. Box 5576
Bakersfield, California 93388

Dear Mr. Starbuck:

This is in response to your letter of March 25, 1986 on the subject of criteria for severe solvent refinement under the Hazard Communication Standard.

Your letter raises two issues relevant to my first letter to you on this issue, dated March 19, 1986. Your first point is that the Halder paper referenced by IARC deals only with paraffinic distillates and thus should not apply to naphthenic oils. You are correct. Our review of the relevant sources demonstrates that no evidence was present in any of the papers cited by IARC that solvent refined naphthenic oils refined at any level of severity produced carcinogenic results in animal testing. Therefore no naphthenic oil which undergoes solvent refining will be regarded by OSHA as carcinogenic under the Hazard Communication Standard until or unless some study which is designed and conducted according to established scientific principles and which reports statistically significant conclusions regarding its health effects is performed. Because there are no positive carcinogenic results for solvent refined naphthenic distillates in the papers referenced by IARC, OSHA concludes that the statement in the IARC Monograph that mildly solvent refined oils are carcinogenic to experimental animals refers to mildly solvent refined paraffinic oils for which there are data, as you acknowledge, in the Halder paper.

Your second point is that Viscosity Index is not an appropriate index to severity of refinement. However, Halder chose to regard it as significant and IARC appeared to rely on his judgment. One of several statements to this effect in the Halder report is on page 267 of that report and states, "The VI is inversely related to the amount of cycloparaffins and aromatic hydrocarbons remaining in an oil and reflects the severity to which the lubricating oil distillates were solvent extracted." Thus, since OSHA relies on the IARC Monograph and the papers upon which it is based, we are forced to conclude that, in the case of paraffinic oils, Viscosity Index is indeed an appropriate measure of severity of refinement.

There are two points, however, about which we believe a modification of our previous interpretation is called for, both of which refer to paraffinic oils. The Halder paper states (page 272) that solvent refining of lubricating oil distillates to produce VI's of 85-100 is sufficient to effectively eliminate dermal carcinogenic activity. However, the actual data cited in Table V of the paper shows carcinogenic activity to exist for mildly solvent refined paraffinic distillates which have not been hydrofinished when the Viscosity Index is 76. No date if presented anywhere in the paper for carcinogenicity at any higher Index. Therefore, OSHA is compelled to clarify its interpretation to consider as carcinogenic only those solvent refined paraffinic distillates whose Viscosity Index is 76 or below. The second modification concerns additives. Since Viscosity Index can be raised by additives without reducing the carcinogenicity of base oil, we are further requiring that the Viscosity Index of the base oil as it leaves the refinery stream be greater that 76 before the finished oil can be exempt from the labelling requirements of the Hazard Communication Standard.

Finally, with regard to your request to exempt the products of San Joaquin Refining Co., Inc. from the labelling requirement of the Hazard Communication Standard, we must again refer to IARC Monograph 33. The Monograph states that, "There is sufficient evidence for the carcinogenicity in experimental animals of untreated vacuum distillates, acid treated oils, and aromatic oils, including extracts from solvent treatment of distillates and the high boiling fraction of catalytically cracked oils (classes 1, 2, and 6)" pp. 150-151. If your products fall into one of these stated categories or any of the other categories identified by IARC as producing carcinogenic products you are required to label appropriately under the Hazard Communication Standard. If your products do not fall into any category defined by IARC as producing carcinogenic effects and there is not other experimental evidence of carcinogenicity then those products are not subject to the labelling requirements of the Standard.

I hope that this information will clarify the points you raised in your letter.

Sincerely,



John B. Miles, Jr., Director
Directorate of Field Operations


Standard Interpretations - Table of Contents

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close