Powered by GoogleTranslate

Occupational Safety and Health Administration OSHA

Inspection Detail

Inspection: 300858925 - Imperial Sign Co. Inc.

Inspection Information - Office: Ca San Bernardino

Nr: 300858925Report ID: 0950633Open Date: 07/23/2002

Imperial Sign Co. Inc.
42-106 Washington St.
Indio, CA 92201
Union Status: NonUnion
SIC: 3993/Signs and Advertising Specialties
Mailing: 46-120 Calhoun St., Indio, CA 92201

Inspection Type:Accident
Scope:Complete Advanced Notice:N
Ownership:Private
Safety/Health:Safety Close Conference:01/10/2003
Close Case:01/31/2003

Related Activity:TypeIDSafetyHealth
 Accident362481483    

Violation Summary
Serious Willful Repeat Other Unclass Total
Initial Violations 1 1
Current Violations 1 1
Initial Penalty $0 $0 $0 $175 $0 $175
Current Penalty $0 $0 $0 $175 $0 $175
FTA Amount $0 $0 $0 $0 $0 $0

Violation Items
# ID Type Standard Issuance Abate Curr$ Init$ Fta$ Contest LastEvent
  1. 01001 Other 23950051 A01 01/10/2003 01/24/2003 $175 $175 $0 -

Accident Investigation Summary
Summary Nr: 201156270Event: 07/23/2002Employee Is Shocked And Dies While Working On Light Fixture
At approximately 1:38 p.m. on July 23, 2002, Employee #1 and his coworker were working on the neon light of an electric sign. Both employees were working in an attic behind the sign. An extension ladder was used for access to the attic through an opening in the ceiling. Just before the accident, Employee #1 replaced a bad transformer, a gas tube transformer, 15030-og-120 V, with a new transformer, neon transformer, primary 120 volts and secondary-15000 volts. The power to the entire sign system was turned off at the main switch. After replacing the transformer, Employee #1 checked the proper function of the new transformer, so he used jumpers (3-wire attachment plug with three alligator clips) to power the transformer by using an extension cord connected to an electrical receptacle inside the store. After connecting the jumper cables to the extension cord, Employee #1 asked his coworker to go and check to see if the sign lights were working. Employee #1's coworker went outside and came back in to inform him that the lights were not working. The coworker saw the light on the sign flicker twice and he heard Employee #1 yell several times. The coworker ran into the work area, where he saw the Employee #1 sitting on the floor holding the jumper cables in his left hand and his legs over a flexible conduit. The coworker stated that the victim was breathing very hard and could not talk. The coworker disconnected the jumper cables from the extension cord and Employee #1 fell to the floor. The coworker informed the owner, who called emergency personnel. Employee #1 was transported to the hospital, where he was pronounced dead.
Keywords: receptacle, repair, conduit, cord set, electrocuted, lighting fixture, lighting, electric shock, transformer
Inspection Degree Nature Occupation
1 300858925 Fatality Electric Shock Electrical power installers and repairers

Thank You for Visiting Our Website

You are exiting the Department of Labor's Web server.

The Department of Labor does not endorse, takes no responsibility for, and exercises no control over the linked organization or its views, or contents, nor does it vouch for the accuracy or accessibility of the information contained on the destination server. The Department of Labor also cannot authorize the use of copyrighted materials contained in linked Web sites. Users must request such authorization from the sponsor of the linked Web site. Thank you for visiting our site. Please click the button below to continue.

Close