Archive Notice - OSHA Archive

NOTICE: This is an OSHA Archive Document, and may no longer represent OSHA Policy. It is presented here as historical content, for research and review purposes only.

Department of Labor Logo
OSHA News Release
Region 2

Please note: As of January 20, 2021, information in some news releases may be out of date or not reflect current policies.

Region 2 News Release: 06-673-NEW/BOS 2006-107
Wednesday, April 19, 2006
Contact: Ted Fitzgerald
Phone: (617) 565-2074

OSHA Fines Oneida County, N.Y., Bus Assembly Plant $116,200

SYRACUSE, N.Y. -- A wide range of safety hazards at an Oriskany, N.Y., assembly plant has resulted in $116,200 in fines from the U.S. Labor Department's Occupational Safety and Health Administration (OSHA).

Orion Bus Industries Inc., which assembles and finishes passenger buses at the 165 Base Road plant, has been cited for a total of 24 alleged willful, serious and other-than-serious violations of safety standards following an OSHA inspection begun Nov. 21, 2005, in response to an employee complaint.

OSHA's inspection found various fall hazards, a locked and blocked emergency exit, defective forklifts, uninspected chain slings, ungrounded electrical equipment, unsafe electrical work practices, unguarded saws and grinders, lack of bonding and grounding while transferring flammable liquids, and failure to record accidents in the plant's illness and injury log.

"Left uncorrected, these conditions expose employees to potential serious injury or death from falls, electrocution, crushing, lacerations, amputation, fire and being unable to exit the workplace swiftly in the event of an emergency," said Chris R. Adams, OSHA's area director for Central New York.

The largest fine, $63,000, was assessed for service bay pits that lacked grating or guarding to prevent employees from falling into them. This resulted in a citation for one willful violation which is one committed with an intentional disregard of, or plain indifference to, the requirements of the Occupational Safety and Health Act and regulations.

A total of $52,200 in fines was proposed for 20 serious citations addressing the exit access, electrical, fire, forklift and sling hazards as well as additional fall hazards from unguarded work areas. Finally, a $1,000 fine was proposed for three other-than-serious citations covering inadequate recordkeeping, an unsecured electrical receptacle and unlabeled containers of chemicals.

A serious citation is issued when death or serious physical harm are likely to result from a hazard about which the employer knew or should have known. Other-than-serious violations are hazardous conditions that would probably not cause death or serious physical harm but would have a direct and immediate relationship to the safety and health of employees.

The company has 15 business days from receipt of its citations and fines to meet with the OSHA area director or contest them before the independent Occupational Safety and Health Review Commission. The investigation was conducted by OSHA's area office located at 3300 Vickery Road, North Syracuse; telephone: 315-451-0808.

Employers are responsible for providing a safe and healthful workplace for their employees. OSHA's role is to assure the safety and health of America's workers by setting and enforcing standards; providing training, outreach and education; establishing partnerships; and encouraging continual improvement in workplace safety and health. For more information, visit

# # #

U.S. Labor Department (DOL) releases are accessible on the Internet at The information in this news release will be made available in alternate format upon request (large print, Braille, audio tape or disc) from the COAST office. Please specify which news release when placing your request. Call (202) 693-7765 or TTY (202) 693-7755. DOL is committed to providing America's employers and employees with easy access to understandable information on how to comply with its laws and regulations. For more information, please visit